Product ID:ACETIC ACID, AX0073T
MSDS Date:03/03/1994
FSC:6810
NIIN:00N084201
MSDS Number: CGSLG

EM SCIENCE

480 DEMOCRAT RD
GIBBSTOWN, NJ 08027
US

Emergency Phone: 800-424-9300(CHEMTREC)

Info Phone: 609-423-6300

Cage: DO242

EM SCIENCE

70 GIBBSTOWN, NJ 08927 US

Telephone: 800-424-9300 (CHEMTREC)

Cage: DO242

ACETIC ACID (CERCLA)

CAS: 64-19-7

RTECS: AF1225000

Fraction By Weight: 100%

OSHA PEL 10 PPM

ACGIH TLV: 10 PPM;15 STEL

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

RISK. TAKE UP & CONTAINERIZE FOR PROPER DISP AS

RTECS: 9999999ZZ

ON REPORTING RELS. REFER TO REGULATORY INFO FOR

RTECS: 9999999ZZ

SPILL-X NEUTRALIZERS & ABSORB AGENTS FOR VARIOUS

RTECS: 9999999ZZ

PROVIDE THRU EM SCIENCE TECHNICAL SERVICE DEPT

RTECS: 9999999ZZ

ACID-RESISTANT PROTECTIVE SUIT W/RUBBER

RTECS: 9999999ZZ

LD50 LC50 Mixture:LD50:(ORAL,RAT) 3530 MG/KG.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:CONTACT CAUSES SEVERE BURNS, EYE
DAMAGE. VAPOR INHALATION CAUSES LACHRYMATION, SEVERE IRRITATION OF
RESPIRATORY PASSAGES; BRONCHITIS, PULMONARY EDEMA AND CHEMICAL
PNEUMONITIS MAY OCCUR. MAY BE FATAL I F SWALLOWED. TEST ON LAB
ANIMALS INDICATE MATERIAL MAY PRODUCE ADVERSE MUTAGENIC AND
REPRODUCTIVE EFFECTS.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:RESPIRATORY CONDITIONS.

First Aid:GET MEDICAL ASSISTANCE FOR ALL CASES OF OVEREXPOSURE.
SKIN:IMMEDIATELY FLUSH THOROUGHLY W/LARGE AMOUNTS OF WATER. REMOVE
CONTAMINATED CLOTHING & WASH BEFORE REUSE. EYES:IMMEDIATELY FLUSH
THOROUGHLY W/ WATER FOR AT LEAST 15 MINUTES. INHAL:REMOVE TO FRESH
AIR; GIVE ARTIFICIAL RESPIRATION IF BREATHING HAS STOPPED.
INGEST:DO NOT INDUCE VOMITING; GET IMMEDIATE MEDICAL ATTENTION.

Flash Point Method:CC
Flash Point:109F,43C
Lower Limits:5.4%
Upper Limits:16%
Extinguishing Media:CO*2, DRY CHEMICAL, "ALCOHOL" FOAM, WATER MIST.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:MODERATE FIRE & EXPLOSION HAZARD. VAPOR
CAN TRAVEL DISTANCES TO IGNITION SOURCE & FLASH BACK.

Spill Release Procedures:EVACUATE AREA OF ALL UNNEC PERS. WEAR SUITABLE
PROT EQUIP LISTED UNDER EXPOS/PERSONAL PROT SECTION. ELIM ANY IGNIT
SOURCES UNTIL AREA IS DETERMINED TO BE FREE FROM EXPLO/FIRE HAZS.
CONTAIN RELS & ELIM ITS SOURCE, IF THIS CAN BE DONE W/OUT (ING 2)
Neutralizing Agent:FOLLOWING EM SCIENCE SPILL-X NEUTRALIZER & ABSORB IS
REC FOR THIS PROD: (SUPDAT)

Handling and Storage Precautions:KEEP CONTAINER TIGHTLY CLOSED. STORE
ABOVE 62F, BUT AWAY FROM DIRECT HEAT, IGNITION SOURCES & OXIDIZERS.
DO NOT BREATHE VAPOR.
Other Precautions:DO NOT GET IN EYES ON SKIN OR ON CLOTHING. RETAINED
RESIDUE MAY MAKE EMPTY CONTAINERS HAZARDOUS; USE CAUTION! DO NOT
TAKE INTERNALLY. HARMFUL IF INHALED. FLAMMABLE LIQUID & VAPOR.

Respiratory Protection:IF WORKPLACE EXPOS LIM(S) OF PROD/ANY COMPONENT
IS EXCEEDED, A NIOSH APPRVD AIR SUPPLIED RESP IS ADVISED IN ABSENCE
OF PROPER ENVIRON CONTROL. OSHA REGS ALSO PERMIT OTHER NIOSH APPRVD
RESPS (NEG PRESS TYPE) UNDER SPECIFIED CNDTNS (SUPDAT)
Ventilation:MATERIAL MUST BE HANDLED OR TRANSFERRED IN AN APPROVED FUME
HOOD OR W/EQUIVALENT VENTILATION.
Protective Gloves:NATURAL RUBBER, NEOPRENE, PVC OR(SUPDAT)
Eye Protection:ANSI APPROVED CHEM WORKERS GOGGS(SUPDAT)
Other Protective Equipment:ANSI APPRVD EYE WASH FOUNTAIN & DELUGE
SHOWER . IMPERVIOUS PROT CLTHG SHOULD BE WORN TO PVNT SKIN CONT.
(ING 6)
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
MATLS TO AVOID:CARBONATES. NEUT AGENT:SX0861 - SPILL-X-A ACID SPILL
TREATMENT KIT. WASTE DISP METH:& FED REGS. RESP PROT:(SEE YOUR SFTY
EQUIP SUPPLIER). ENGINEERING &/OR ADMIN CONTROLS SHOULD BE IMPLE
MENTED TO REDUCE EXPOS. PROT GLOVES:EQUIVALENT GLOVES. EYE PROT:&
FULL LENGTH FACESHIELD .

Boiling Pt:B.P. Text:245F,118C
Melt/Freeze Pt:M.P/F.P Text:62.1F,16.7C
Vapor Pres:11.4 @ 20C
Vapor Density:2.07
Spec Gravity:1.049 (H*2O=1)
Evaporation Rate & Reference:0.97 (BUTYL ACETATE=1)
Solubility in Water:MISCIBLE
Appearance and Odor:CLEAR, COLORLESS LIQUID; PUNGENT ODOR.
Percent Volatiles by Volume:100

Stability Indicator/Materials to Avoid:YES
OXIDIZERS, STRONG ALKALIES, METALS, AMINES, CYANIDES, SULFIDES, CHROMIC
ACID, NITRIC ACID, HYDROGEN PEROXIDE, (SUPDAT)
Stability Condition to Avoid:HEAT; CONTACT W/IGNITION SOURCES. DILUTED
ACID REACTS W/METALS TO PRODUCE FLAMMABLE HYDROGEN GAS.
Hazardous Decomposition Products:CO*X.

Waste Disposal Methods:EPA WASTE NUMBERS:D002, D001. SPECIFIED
TECHNOLOGY - NEUTRALIZE TO PH 6-9. CONT YOUR LOC PERMITTED WASTE
DISP SITE (TSD) FOR PERMISSIBLE TREATMENT SITES. ALWAYS CONT
PERMITTED WASTE DISPOSER (TSD) TO ASSURE COMPLIANCE W/ALL CURRENT
LOC, STATE(SUPDAT)

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.